# Radiator Cap Replacement in Upland > A worn radiator cap lets coolant boil early. Route 66 Auto Repair in Upland tests the cap against its rating and replaces it with the correct part. Source: https://route66autorepairshop.com/cooling-heating-ac-services/radiator-cap-replacement Updated: 2026-09-17 Business: Route 66 Auto Repair, 1775 W Foothill Blvd, Upland, CA 91786, (909) 608-7699 Hours: Monday to Friday 8 AM–5 PM, Saturday 8 AM–2 PM, Sunday closed **TLDR:** A cap that opens early lowers the **boiling point** and pushes coolant out. We **test the cap** against its rating before calling it bad. The radiator cap is a small valve that holds the cooling system at pressure, which raises the boiling point of the coolant. Route 66 Auto Repair in Upland tests your cap on a pressure tester against its rated value and replaces it if it opens early or leaks. It is a small part, but a weak cap can make a healthy engine boil over on a hot climb. ## What are the signs of a bad radiator cap? - Reservoir overfills when hot and never draws coolant back - Upper radiator hose collapses after the engine cools - Coolant crust around the cap or filler neck - Boil-over on hot days with no other leak found - Rubber seal on the cap is cracked, flattened or missing ## What does the radiator cap actually do? The cap has two valves. The main spring holds pressure in the system until it reaches the rated value, then lets excess coolant into the overflow. A small vacuum valve lets that coolant flow back as the engine cools. If either valve sticks, the level goes wrong and the engine runs closer to boiling than it should. On many newer cars the pressure cap sits on the reservoir instead of the radiator. The test is the same. If your reservoir itself is cracked, see [coolant reservoir replacement](https://route66autorepairshop.com/cooling-heating-ac-services/coolant-reservoir-replacement). The rated value is printed right on the cap. Passenger vehicle caps commonly fall in the range of about 13 to 16 psi, and that pressure matters because every additional psi raises the boiling point of the coolant by roughly 3 degrees F. A cap venting early gives up that margin exactly when a grade or a summer afternoon needs it. Those ranges are general; the rating your vehicle maker specifies is the one a replacement cap has to match. ## Our radiator cap process 1. **Check the rating:** We read the pressure rating stamped on the cap and confirm it matches your vehicle. 2. **Bench test:** The cap goes on an adapter and is pumped up to see where it opens and whether it holds. 3. **Inspect the neck:** The filler neck is checked for nicks or corrosion that would stop any cap from sealing. 4. **Replace and confirm:** A correct cap is installed and the system is pressure tested with it in place. ## What's included in radiator cap replacement - Cap pressure and vacuum valve test - Filler neck inspection - Replacement cap with the correct rating - System pressure test with the new cap - Coolant level correction ## Is it a need-now or need-later repair? **Need now:** - Cap fails the pressure test - Boil-over or coolant pushed out of the overflow **Need later:** - Cap passes but the seal is starting to harden - Replacing the cap at the next coolant service as a precaution ## How pricing and timing work The cap itself is a small line on the estimate, and the test takes minutes. If the cap passes and coolant is still disappearing, the real cause is elsewhere, and we explain a full [cooling system pressure test](https://route66autorepairshop.com/cooling-heating-ac-services/cooling-system-pressure-test) before anything else is charged. A damaged filler neck usually means a radiator or reservoir repair instead. ## Aftercare Only open the cap when the engine is fully cold. Keep the level at the cold line on the reservoir. If you still see coolant pushed into the overflow after a drive, bring it in; that pattern can point to a combustion leak, which our [coolant system diagnostic](https://route66autorepairshop.com/cooling-heating-ac-services/coolant-system-diagnostic) covers. ## Frequently asked questions ### Can a bad radiator cap cause overheating? Yes. A cap that opens early lets coolant boil sooner and pushes it out of the system, so the level drops and the engine runs hot on a long grade. ### Should I buy a higher pressure cap for more cooling? No. Hoses, the radiator and the heater core are built for the rated pressure. A stronger cap can burst a hose or a tank. Use the value your vehicle specifies. ### Why is it dangerous to open a hot radiator cap? Hot coolant under pressure can flash to steam and spray out when the cap is loosened. Let the engine cool completely first. --- Call (909) 608-7699 or visit https://route66autorepairshop.com/contact for a written estimate.