# Radiator Fan Temperature Switch Repair in Upland > Fan never kicks on or won't shut off? Route 66 Auto Repair in Upland tests the radiator fan temperature switch and its circuit, then replaces what failed. Source: https://route66autorepairshop.com/cooling-heating-ac-services/radiator-fan-switch-repair Updated: 2026-09-17 Business: Route 66 Auto Repair, 1775 W Foothill Blvd, Upland, CA 91786, (909) 608-7699 Hours: Monday to Friday 8 AM–5 PM, Saturday 8 AM–2 PM, Sunday closed **TLDR:** If the fan never runs, or **never stops**, the **temperature switch** is a common suspect. We prove it with a circuit test before replacing it. On many older vehicles and some newer ones, a temperature switch turns the radiator fan on and off. It sits in the radiator tank or engine and closes a circuit when coolant gets hot. When it fails, the fan either never runs or never stops. Route 66 Auto Repair in Upland tests the switch and its wiring, proves the fan motor works, and replaces only the part that failed. ## What are the signs of a bad fan switch? - Fan never comes on, even with the gauge high - Fan runs all the time, even with a cold engine - Battery drained because the fan runs after the car is off - Coolant seep at the switch threads - Engine overheats in traffic but is fine on the freeway ## Does your vehicle use a switch or a computer? Older designs use a thermo switch that directly controls the fan relay. Many newer vehicles let the engine computer decide, using the coolant temperature sensor, and there is no switch at all. Some use both: the computer runs the fan normally, and a separate switch acts as a backup at high temperature. Knowing which design you have avoids buying a switch your car does not use. If your vehicle has a relay between the switch and the fan, that relay can fail too, and it is covered on [radiator fan relay repair](https://route66autorepairshop.com/cooling-heating-ac-services/radiator-fan-relay-repair). Computer-controlled fans usually trace back to the sensor on [cooling system temperature sensor repair](https://route66autorepairshop.com/cooling-heating-ac-services/cooling-system-temperature-sensor-repair). ## Our fan switch repair process 1. **Identify the design:** We confirm how your fan is controlled and where the switch sits. 2. **Bypass test:** With the switch unplugged, we apply a safe test signal to see whether the fan runs. 3. **Test the switch:** Continuity is checked cold and hot to see whether the switch closes at the right point. 4. **Replace and verify:** A new switch is installed with a new seal, coolant is topped up, and the fan cycle is watched at temperature. ## What's included in fan switch repair - Fan control design check - Fan bypass and switch continuity tests - Wiring and connector inspection - New switch with seal - Coolant top-off and fan cycle verification ## Is a failed fan switch urgent? **Need now:** - Fan will not come on and temperature rises - Fan runs with the key off and drains the battery - Coolant leaking from the switch **Need later:** - Fan comes on a little late with normal temperatures - Connector with light corrosion and a working fan ## How pricing and timing work Switches are usually small parts. Access and coolant loss drive the labor. The diagnostic fee is stated at the counter before testing and applies to approved related repair. You get a written estimate before any part is ordered. Switch replacements are commonly done the same day when the board allows. ## After the repair Listen for the fan to cycle on in traffic and off once the engine cools. It is normal for some fans to run briefly after shutdown. If the battery goes flat again, call [(909) 608-7699](tel:+19096087699) and we will check the circuit. ## Frequently asked questions ### Can I wire my fan to run all the time? It can get you home in an emergency, but it wears the fan and drains the battery. It is not a repair. ### Why does the fan run after I shut the car off? Some designs do that on purpose for a short time. If it runs until the battery dies, the switch or relay may be stuck. ### Does the switch affect the AC? On some vehicles, the AC also turns on the fan through a separate path. We check both so the AC and engine cooling work. --- Call (909) 608-7699 or visit https://route66autorepairshop.com/contact for a written estimate.