# Electrical Short Circuit Repair in Upland > Fuses keep blowing? Upland short circuit repair traces the shorted wire or part, repairs it and protects the circuit so the fuse holds. Source: https://route66autorepairshop.com/electrical-services/electrical-short-circuit-repair Updated: 2026-09-17 Business: Route 66 Auto Repair, 1775 W Foothill Blvd, Upland, CA 91786, (909) 608-7699 Hours: Monday to Friday 8 AM–5 PM, Saturday 8 AM–2 PM, Sunday closed **TLDR:** A fuse that keeps **blowing** is a symptom. We find the **shorted wire or part**, fix it, and protect the circuit so it does not happen again. A short circuit happens when power finds a path to ground that bypasses the part it was meant to run, so the fuse blows or wires overheat. Route 66 Auto Repair in Upland traces shorts that keep blowing fuses, cause a burning smell or kill a system without warning. Our ASE-certified technicians find the exact spot, show you the damage, and repair it on a written estimate so the new fuse holds. ## What are the warning signs of a short? If you see smoke or smell burning, pull over, turn the car off and do not drive it. Call [(909) 608-7699](tel:+19096087699). Tow-ins are accepted. - The same fuse blows again right after you replace it - A fuse blows only on bumps, turns or in the rain - A burning plastic smell from the dash or engine bay - Smoke or melted insulation near a wire ## How do we trace a short without guessing? We never install a larger fuse. Instead we connect a protected test device in place of the fuse so the circuit can be powered safely while we unplug parts and flex wires. When the short goes away, we know which section holds it. Common causes are chafed wires on sharp metal, water in a connector, a failed motor, and pinched wiring from aftermarket installs. Damage behind panels is photographed before repair. On a hybrid, tell us it is a hybrid at intake and we will explain what we can take on. ## Our short circuit repair process 1. **Make it safe:** The burned fuse is removed and the circuit is checked for heat damage. 2. **Power it with protection:** A protected test device replaces the fuse so we can trace safely. 3. **Isolate the section:** Parts are unplugged and wires flexed until the short clears. 4. **Repair the cause:** The chafed wire, wet connector or shorted part is repaired or replaced, and the run is protected. 5. **Confirm:** The correct fuse is installed and the circuit is run under load and on a road test. ## What's included in short circuit repair - Heat damage inspection on the affected circuit - Protected short tracing - Photos of the shorted section - Wire, connector or part repair as quoted - Loom or clip protection at the repair - Correct fuse installed and load test ## Is a short circuit a need-now repair? **Need now:** - Any smoke, melting or burning smell - A blown fuse for lights, wipers, fuel or engine control - A short that drains the battery **Need later:** - A blown fuse for a feature you do not use, with no heat damage - An accessory outlet fuse that blew once from a bad charger - A dome light fuse after a known pinched wire in a trunk lid ## How pricing and timing work Tracing time depends on where the short hides. The diagnostic fee is stated at the counter before testing and applies to approved related repair. If tracing runs longer than approved, we stop and call. Repairs go on a written estimate. AAA members get 10% off parts and labor, up to $75, with the card at time of service. Shorts that only happen on the road may need a drop-off. ## Aftercare Carry a spare fuse of the correct rating only. If a new fuse blows, stop using that circuit and call us; a comeback goes to the front of the line. Related help: [wiring harness repair](https://route66autorepairshop.com/electrical-services/wiring-harness-repair), [fuse testing](https://route66autorepairshop.com/electrical-services/electrical-system-fuse-testing) and [wiring loom repair](https://route66autorepairshop.com/electrical-services/wiring-loom-repair). ## Frequently asked questions ### Can I just put in a bigger fuse? No. The fuse protects the wire. A bigger fuse lets the wire overheat before anything blows, which can start a fire. Always use the rating shown on the fuse box cover. ### Why does my fuse only blow in the rain? Water is getting into a connector or reaching a wire with worn insulation. We can wet the area in the bay to reproduce it, which helps find the exact spot. ### Is a short circuit covered by warranty? Coverage depends on the part and the repair and is written on the invoice. If the short came from a part we installed, bring it in and it goes to the front of the line. --- Call (909) 608-7699 or visit https://route66autorepairshop.com/contact for a written estimate.